Home > Dodge Neon > 2005 Dodge Neon Radiator Fan Not Working

2005 Dodge Neon Radiator Fan Not Working

Contents

The fans are not coming on. With the ignition OFF, put one end into the power connection for the relay and the other into one of the fan's power connections in the relay box. What would cause this? mike in nj, why are you so upset? http://elliottwaveresearch.com/dodge-neon/2005-dodge-neon-fan-relay-location.html

Low voltage allows the clutch to slip, which creates excessive friction and heat. hellcat1988 Mahnomen, MN #4 Apr 19, 2011 My only other suggestions would be to check if the wiring is still good between the fan, and relay. The back plate of the relay is used for the ground and pin 1 and 2 are "control" pins used to complete the circuit to energize the relay which in turn My radiator looked fine from the front(No A/C condenser in a circle track car), but when I pulled it to take it in to be flow tested, I found the cooling

2005 Dodge Neon Radiator Fan Not Working

If you can feel that the radiator is hot, then there is also a sensor which turns the fan on to a higher speed which may have failed. I’ve read about a block off for the EGR but I would like the light to go out, because (and I may be wrong) I want the car to go into Judged: 11 Reply » Report Abuse Judge it! Enter your email to get updates when people reply.

  1. Alexey Gavrilov 16.235 visualizaciones 9:01 Throttle Body Dodge Neon 02 - Duración: 8:17.
  2. AMR Athens, GA #9 Sep 3, 2013 My fans aren't working.
  3. Expand» Details Details Existing questions More Tell us some more Upload in Progress Upload failed.

Thanks in advance. ‘98 Plymouth Neon, 2.0”Y” DHOC, MTX, ATX throttle body Top geewhiz New Posts: 15 Joined: Thu Oct 07, 2010 8:33 am Location: Black Earth, WI Re: Radiator Fan I don't question your knowledge or ability at all, and am glad for any advice you care to give regarding automobile maintenance and repair. These use a solid state relay for the cooling fans, and the relays tend to overheat and fail. 2002 Dodge Neon Radiator Fan Not Working All rights reserved.

The quickest way to tell whether or not the electric fan(s) are working is to start the engine, let it reach normal operating temperature and then turn the A/C on. Unrelated to fan problem I also replaced the radiator cap and thermostat. Maybe a common bad ground that both fans share? All rights reserved.

We have jumped the fan off using a wire in the relay box under the hood and have gotten it to work upon starting the vehicle, but after the engine has 2005 Dodge Neon Cooling Fan You can only upload a photo (png, jpg, jpeg) or a video (3gp, 3gpp, mp4, mov, avi, mpg, mpeg, rm). no leaks, etc. It seems to me if it were the fan motors, both wouldn't go bad at the same time.

2005 Dodge Neon Fan Relay Location

and i have replaced a very 'few' of them, it's not always the relay. I purchased and replaced the old relay with a new one and still this problem, the fans work with the wire(jumping it off), but it will not work with any relay 2005 Dodge Neon Radiator Fan Not Working I found out the relay is not the standard relay you usually find under the hood. 2004 Dodge Neon Radiator Fan Not Working Pressure prevents premature boiling over, which would lead to overheating.2.

Chrysler LH cars (since early 1990s). check over here The PCM activates the relay by grounding Pin 2. Check the drive belt and replace if broken or showing cracks. Upvote Flag inappropriate«12»Related Items:Defective RFI Fan Filter May Cause Vehicle to OverheatIf the vehicle overheats because the cooling fan is not turning on, or if the AC is not working...Verified for 2004 Dodge Neon Fan Relay Location

Cargando... The wires look ok by the EGR also.I think I’ve done enough searching to find my answer if it was out there, so I’m going to resort to asking you all Añadir a ¿Quieres volver a verlo más tarde? http://elliottwaveresearch.com/dodge-neon/2005-dodge-neon-fuse-box-diagram.html Environmental Protection Agency (EPA) and California Air Resources Board (CARB) emission regulations.

Some how, in trying to diagnose the EGR code, I have discovered that the fans do not run. 2002 Dodge Neon Overheating Problems I'm going to give it a test and try to ground the wire while the engine is running and see if this fires up the fans.But so far no luck what If the radiator is hot, find out where the sensor is, check the wiring and replace both sensor and wiring if necessary.

Yesterday after coming home from work I let it idle again as I got the mail and nothing, I wiggled the wiring harness and some of the grounds, still nothing.Any thoughts?

Click the Banner Below to Ask an Expert: Related Articles: Overheating: Causes & Cures Coolant Sensors Troubleshoot Electric Cooling Fan Troubleshoot Cooling Fan Clutch Click Here to See More Carley Automotive I will try this next. Our Daily Bread - Practical Tips for a Fulfilling LifeHyperPhysics - The World of Physics2006 Volvo V70R - 300 hp; 295 ft lb Top zerko New Posts: 20 Joined: Tue Jun 2001 Dodge Neon Radiator Fan Not Working Use a test light to test for power and ground at the motor. 03-26-04,11:45 PM #4 mike from nj Visiting Guest yes, you could replace all those expensive parts, and still

The EGR seems to pass the mechanical test and the resistance in the control valve matches what I’ve read here, but I have one coming from another member to try to Let me know what you eventually find to be the problem. Dual relay. http://elliottwaveresearch.com/dodge-neon/2005-dodge-neon-turn-signal-problems.html Pin 1 serves no "functional" purpose.

Check the condition of your radiator. If i cannot figure out the issue im just going to wire it up manually using a standard 12v 30amp relay. diversity2 39.138 visualizaciones 10:07 Cargando más sugerencias... Inicia sesión para añadir este vídeo a una lista de reproducción.

Contact Us DoItYourself.com Mobile Site Privacy Statement Top All times are GMT -7. Cargando... it might take some convincing, and politeness helps. Sponsored Links 03-26-04,02:28 PM #2 Pete112 Member Join Date Mar 2004 State NJ Posts 137 Try hooking one or both of them directly to power without the switch...

In very hot tempertures the coolant reservoir begins to bubble. Mostrar más Cargando... Find the schematic to that car and short the contact to see if it wants to turn on. In many cases, the underlying fault is a bad cooling fan relay.

Advertise Find a Contractor Interactive How-to's About Us Terms of Use Privacy Policy Cookie Policy Site Map DoItYourself.com is an INTERNET BRANDS company. It's rather thin, but it is a VERY important ground. Make sure it's not corroded and tight. Involved vehicles must have the recall service completed before registration renewal.

even when engine temprature in cluster is pick high they sometimes spin slow sometimes don't spin at all...i checked all relays and fuses.. It is so worth it in the long run though. Why does my Dodge Neon overheat? Unrelated to fan problem I also replaced the radiator cap and thermostat.

On this vehicle, you should use a scan tool to see which of these inputs is energizing the fans and when.